Product ID:SHELL REGULAR GASOLINE
MSDS Date:10/11/1985
FSC:9130
NIIN:00B190052
MSDS Number: BBBWX

SHELL OIL COMPANY

HOUSTON, TX
US

Emergency Phone: 713473-9461-800424-9300

Info Phone: 713241-4819

Cage: 54527

SHELL OIL COMPANY

2463 HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 0-25.0%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 0-25.0%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: 0.5-2.5%

OSHA PEL 1PPM/5STEL;1910.1028

ACGIH TLV: 10 PPM; A2; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

TETRAETHYL LEAD (SARA III)

CAS: 78-00-2

RTECS: TP4550000

Fraction By Weight: <0.1% GM

OSHA PEL S, 0.075MG/M3(PB)

ACGIH TLV: S, 0.1 MG/M3(PB)9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYE CONTACT:MODERATELY IRRITATING TO
THE EYES.SKIN CONTACT:PROLONGED AND REPEATED LIQUID CONTACT CAN
CAUSE DEFATTING AND DRYING OF THE SKIN RESULTING IN SKIN IRRITATION
AND DERMATITIS.INHALATION:PRODU CT MAY CAUSE IRRITATION TO THE
NOSE,THROAT AND RESPIRATORY TRACT.INGESTION:HARMFUL OR FATAL IF
SWALLOWED.
Effects of Overexposure:EARLY TO MODERATE CENTRAL NERVOUS SYSTEM
DEPRESSION MAY BE EVIDENCED BY GIDDINESS,HEADACHE,DIZZINESS AND
NAUSEA;IN EXTREME CASES,UNCONSCIOUSNESS AND DEATH MAY
OCCUR.ASPIRATION PNEUMONITIS MAY BE EVIDE NCED BY COUGHING.LABORED
BREATHING AND CYANOSIS.KIDNEY&LIVER DAMAGE MAY OCCUR,CHANGES IN
URINE,JAUNDICE,PAIN IN ABDOMEN.
Medical Cond Aggravated by Exposure:EYE,SKIN AND RESPIRATORY DISORDERS
MAY BE AGGRAVATED BY EXPOSURE.IMPAIRED LIVER AND KIDNEY DISORDERS
MAY BE AGGRAVATED BY EXPOSURE.

First Aid:EYE CONTACT:FLUSH WITH WATER FOR 15 MIN.WHILE HOLDING EYELIDS
OPEN.GET MEDICAL ATTENTION.INHALATION:REMOVE VICTIM TO FRESH AIR
AND PROVIDE OXYGEN IF BREATHING IS DIFFICULT.GIVE ARTIFICIAL
RESPIRATION IF NOT BREATHING.GET MEDICAL ATTEN.INGESTION:DO NOT
INDUCE VOMITING.IF VOMITING OCCURS SPONTANEOUSLY KEEP HEAD BELOW
HIPS TO PREVENT ASPIRATION OF LIQUID INTO LUNGS.GET MEDICAL
ATTENTION.

Flash Point Method:TCC
Flash Point:-40
Lower Limits:1.3
Upper Limits:7.6
Extinguishing Media:USE WATER FOG,FOAM,DRY CHEMICAL OR CO2.DO NOT USE
DIRECT STREAM OF WATER.PRODUCT FLOATS,CAN BE REIGNITED ON
SURFACE/H2O.
Fire Fighting Procedures:EXTREMELY FLAMMABLE.DO NOT ENTER CONFINED FIRE
SPACE WITHOUT FULL BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR.DO NOT
WELD,HEAT OR DRILL ON OR NEAR CONTAINER.IF EMERGENCY SITUATIONS
REQUIRE DRILLING,ONLY EMER.PERSONNEL SHOULD DRILL.

Spill Release Procedures:DANGER.EXTREMELY FLAMMABLE.ELIMINATE ALL
IGNITION SOURCES.HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT
SPARKING.LARGE SPILLS:ISOLATE HAZARD AREA.SHUT OFF SOURCE OF
LEAK,DIKE AND CONTAIN.SOAK UP WITH ABSORBENT SUCH AS SAND OR
CLAY.FLUSH WITH WATER.

Handling and Storage Precautions:ALL HANDLING EQUIPMENT MUST BE
GROUNDED TO PREVENT SPARKING.
Other Precautions:COOL FIRE EXPOSED CONTAINERS WITH WATER.KEEP OUT OF
SURFACE WATERS AND ANY WATER COURSES OR SEWERS ENTERING OR LEADING
TO SURFACE WATERS.DO NOT USE AS A CLEANING SOLVENT OR FOR OTHER
NON-MOTOR FUEL US ES.

Respiratory Protection:UNDER CONDITIONS OF POTENTIAL HIGH EXPOSURE,THE
USE OF A NIOSH-APPROVED RESPIRATOR IS RECOMMENDED.PER 29 CFR
1910.134 USE EITHER AN ATMOSHPHERE-SUPPLYING RESPIRATOR OR AN
AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:EYE PROTECTION IS REQUIRED.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO MINIMIZE SKIN
CONTACT.
Work Hygienic Practices:WASH WITH SOAP AND WATER BEFORE
EATING,DRINKING,SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
IT HAS BEEN REPORTED THAT CHRONIC INHALATION EXPOSURE TO AN UNLEADED
MOTOR GASOLINE,WHICH WAS FULLY VAPORIZED,HAS PRODUCED KIDNEY AND
LIVER CANCERS IN SOME LABORATORY RODENTS.THE STUDIES WERE SPONSORE
D BY THE AMERICAN PETROLEUM INSTITUTE.SHELL UNLEADED GASOLINE HAS
NOT BEEN EVALUATED IN THIS TYPE OF ANIMAL TEST.

Boiling Pt:B.P. Text:100-425 APP
Vapor Pres:7-14.5
Vapor Density:3.5
Spec Gravity:0.72-0.76
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BRONZE COLOR,CLEAR AND BRIGHT LIQUID,HYDROCARBON
ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
AVOID HEAT,SPARKS,OPEN FLAMES AND STRONG OXIDIZING AGENTS.PREVENT VAPOR
ACCUMULATION.
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER UNIDENTIFIED
ORGANIC COMPOUNDS CAN BE FORMED UPON COMBUSTION.

Waste Disposal Methods:THIS MATERIAL IS A PRODUCT NOT A WASTE.IF
DISCARDED AS IS,IT IS A LIQUID IGNITIBLE HAZARDOUS WASTE AS DEFINED
IN RCRA.PRODUCT RECOVERY AND RECYCLING ARE RECOMMENDED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.